{"id":4367,"date":"2019-06-20T15:39:28","date_gmt":"2019-06-20T15:39:28","guid":{"rendered":"https:\/\/charcoalmachines.com\/?p=4367"},"modified":"2024-03-29T16:26:10","modified_gmt":"2024-03-29T08:26:10","slug":"how-to-make-charcoal-with-the-airflow-hoisting-carbonization-furnace-step-by-step","status":"publish","type":"info","link":"https:\/\/charcoalmachines.com\/id\/how-to-make-charcoal-with-the-airflow-hoisting-carbonization-furnace-step-by-step\/","title":{"rendered":"Bagaimana cara membuat arang dengan furnace karbonisasi angin langkah demi langkah?"},"content":{"rendered":"

The airflow hoisting carbonization furnace is composed of the movable outer stove, inner stove, airflow pipes, ignition port, hoisting equipment, and the flue gas purification equipment<\/b><\/strong><\/a>. The inner stove is independent so that the charcoal furnace can be a single inner stove, three inner stoves, and four inner stoves. The carbonization inner stoves are connected by pipes, and the combustible gas in the carbonization process<\/b><\/strong> can burn each inner furnace which has high working efficiency and can save fuel consumption.<\/p>\n\n\n\n

\"Furnace
Furnace karbonisasi angin angin 1<\/figcaption><\/figure>\n\n\n\n

Rincian proses pembuatan arang dengan <\/b><\/strong>Tungku karbonisasi aliran udara<\/b><\/strong>:<\/b><\/strong><\/h2>\n\n\n\n

Tahap 1: proses pengeringan<\/h3>\n\n\n\n

After placing the inner stove which is of the biomass rods in the arang <\/b><\/strong>furnace<\/b><\/strong>, to ignite at the ignition port below the furnace, and the temperature in the furnace is gradually heated from normal temperature to about 100 \u00b0C. Because the temperature inside the furnace before ignition is low, this process should be heated with a large fire, reaching 100 degrees to the left, and then use a small fire to heat the carbonization<\/b><\/strong> temperature<\/b><\/strong> to 170 \u00b0 C – 200 \u00b0 C or so.<\/p>\n\n\n\n

Tahap 2: proses pirolisis<\/h3>\n\n\n\n

When the temperature in the carbonization furnace reaches 170 \u00b0 C – 200 \u00b0 C, use a simmer to heat the furnace temperature to about 340 \u00b0 C. The second phase takes about 2 hours and 30 minutes.<\/p>\n\n\n\n

\"Tungku
furnace karbonisasi angin angin 2<\/figcaption><\/figure>\n\n\n\n

Tahap 3: proses pirolisis cepat<\/h3>\n\n\n\n

When the temperature in the furnace reaches about 340 \u00b0C, use a small fire to heat the furnace temperature<\/b><\/strong><\/a> from 340 \u00b0C to 380 \u00b0C – 400 \u00b0C. The third phase takes about 2 hours.<\/p>\n\n\n\n

Tahap 4: akhir dari karbonisasi<\/h3>\n\n\n\n

Ketika suhu dalam tungku mencapai sekitar 400 \u00b0C, tidak ada perubahan suhu yang signifikan setelahnya. Gunakan api kecil untuk memanaskan, ketika keluarnya asap dari saluran asap berkurang secara signifikan dan menjadi ringan, nyala api dipadamkan dan proses karbonisasi selesai. Tahap keempat ini memakan waktu sekitar 40 menit.<\/p>\n\n\n\n

Tahap 5: Proses pendinginan dan pelepasan arang<\/h3>\n\n\n\n
\n\n<\/figure>\n\n\n\n

After the carbonization is completed, if no other cooling measures are taken, the fire can be sealed and the charcoal can be naturally cooled. There are two ways to seal fires: Method 1: seal the smoke outlet and cool the charcoal, and the surface of the briket arang<\/b><\/strong><\/a> is good. This method takes about 16 hours to cool down the charcoal. Method 2: completely open the smoke outlet and cool the charcoal. This process is the same as method 1, but the charcoal surface is not shiny like the former. This method takes about 16 hours for cooling. In these two ways, when the temperature in the furnace drops to about 40\u00b0C, to discharge the charcoal is ideal.<\/p>\n\n\n\n

Peralatan produksi arang untuk dijual<\/strong><\/h2>\n\n\n\n
\"batang
batang arang<\/figcaption><\/figure>\n\n\n\n

Note: If there is no temperature measuring device or temperature measuring device damaged in the Tungku karbonisasi aliran udara<\/a><\/b><\/strong>, the small-fire firing in the carbonization process shall take 7-8 hours. It is strictly forbidden to use a large fire during the carbonization process. At the end of carbonization, when the amount of smoke from the outlet is significantly reduced and the smoke is light, the flame should be extinguished and the carbonization is over.<\/p>","protected":false},"excerpt":{"rendered":"

The airflow hoisting carbonization furnace is composed of the movable outer stove, inner stove, airflow pipes, ignition port, hoisting equipment, and the flue gas purification equipment. The inner stove is independent so that the charcoal furnace can be a single inner stove, three inner stoves, and four inner stoves. The carbonization inner stoves are connected […]<\/p>\n","protected":false},"author":1,"featured_media":4369,"parent":0,"comment_status":"open","ping_status":"open","template":"","meta":{"wpai_generated_summary":""},"tags":[23,6,52],"info-type":[2],"class_list":["post-4367","info","type-info","status-publish","has-post-thumbnail","hentry","tag-carbonization-furnace","tag-charcoal-machine","tag-charcoal-making-machine","info-type-faq"],"_links":{"self":[{"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/info\/4367","targetHints":{"allow":["GET"]}}],"collection":[{"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/info"}],"about":[{"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/types\/info"}],"author":[{"embeddable":true,"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/users\/1"}],"replies":[{"embeddable":true,"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/comments?post=4367"}],"wp:featuredmedia":[{"embeddable":true,"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/media\/4369"}],"wp:attachment":[{"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/media?parent=4367"}],"wp:term":[{"taxonomy":"post_tag","embeddable":true,"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/tags?post=4367"},{"taxonomy":"info-type","embeddable":true,"href":"https:\/\/charcoalmachines.com\/id\/wp-json\/wp\/v2\/info-type?post=4367"}],"curies":[{"name":"wp","href":"https:\/\/api.w.org\/{rel}","templated":true}]}}